Problem Lookup › Chevrolet › Express › 2015
Car problem report
2015 Chevrolet Express problems, recalls and owner complaints
What the 2015 Chevrolet Express has been recalled for and what owners report, from official government data. Updated October 25, 2026.
- 0safety recalls
- 9owner complaints
- 0crash reports
- 0fire reports
- 0injuries reported
9 complaints, against an average of 16 for the other 12 Chevrolet Express model years.
Every Chevrolet Express model year with its number of owner complaints. Pick a year to compare.
What goes wrong with the 2015 Chevrolet Express?
The components named most often in the 9 owner complaints. One complaint can name several, so the shares can add up to more than 100%.
Has the 2015 Chevrolet Express been recalled?
NHTSA lists no safety recalls for the 2015 Chevrolet Express as of October 25, 2026. Recalls can be issued at any time, so check your VIN before you rely on this.
What do 2015 Chevrolet Express owners report?
8 of the 9 complaints, the most recent for the most-reported components, as the owners wrote them. NHTSA removes names and VINs; long reports are trimmed. CarHooq has not verified individual claims.
The contact owns a 2015 Chevrolet Express. The contact stated that she could not place compressed natural gas into the tank of her vehicle. The contact was able to find the required gas in another state; however, the vehicle ran out of gas on the return home. The contact had initially towed the vehicle to a local dealer and was informed that they did not have an available service technician to repair her vehicle. The contact then called Weston Buick GMC (22555 SE Stark St, Gresham, OR 97030) where she towed the vehicle after she was assured that the vehicle could be serviced by the dealer…
TL* THE CONTACT OWNS A 2015 CHEVROLET EXPRESS. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED, RESTARTED, AND THE CHARGING SYSTEM INDICATOR ILLUMINATED. THE CONTACT CALLED WALKER CHEVROLET (3940 CAROTHERS PKWY, FRANKLIN, TN 37067, 615-538-5184) AND WAS INFORMED TO SCHEDULE A SERVICE APPOINTMENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 24,000.
I PURCHASED THIS VEHICLE USED, HAVE HAD AN ONGOING PROBLEM WITH THE "STABILITRAK SERVICE" LIGHT COMING ON, HAVE HAD IT INTO THE SHOP "AUTOTIRE" FOR SERVICE 2 TIMES, THEY HAVE REPLACED THE "STEERING WHEEL MOTION SENSOR" AND HAD THE "ANGLE SENSOR" NEITHER HAVE FIXED THE PROBLEM. WHILE THERE IS NO RECALL FOR THIS THERE SHOULD BE, SOUNDS LIKE A DESIGN FLAW WITH NO APPARENT SOLUTION, THE "SERVICE STABILITRAK" LIGHT COMES ON ALL THE TIME, NO MATTER IF VAN IS SETTING STILL, DRIVING, EVEN IN PARK. I AM NOT REAL SURE WHO TO CONTACT WITH SOMETHING LIKE THIS WITHOUT BEING CHARGED HUNDREDS IF NOT…
TL* THE CONTACT OWNS A 2015 CHEVROLET EXPRESS. WHILE THE VEHICLE WAS STATIONARY, ALL OF THE LOCKS ON THE VEHICLE MALFUNCTIONED. THE CONTACT COULD NOT USE THE IGNITION KEY TO OPEN ANY OF THE DOORS. CHAMPION CHEVROLET IN RENO, NEVADA WAS MADE AWARE OF THE FAILURE AND REPLACED ALL OF THE DOOR LOCKS AND THE IGNITION CYLINDER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 36,961.
TL* THE CONTACT OWNS A 2015 CHEVROLET EXPRESS. WHILE THE VEHICLE WAS STATIONARY, ALL OF THE LOCKS ON THE VEHICLE MALFUNCTIONED. THE CONTACT COULD NOT USE THE IGNITION KEY TO OPEN ANY OF THE DOORS. CHAMPION CHEVROLET IN RENO, NEVADA WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 25,730.
WHILE DRIVING OUT OF A MOUNTAINOUS AREA, THE BRAKES APPEARED TO WARP, WHICH RESULTED IN THE VAN SHAKING VIOLENTLY WHEN THE BRAKES WERE APPLIED. ONCE WE WERE BACK ON LEVEL GROUND THE BRAKES APPEARED TO COOL DOWN AND THE SHAKING STOPPED WHEN THE BRAKES WERE APPLIED. THE FRONT END ALIGNMENT WAS DONE 11/16/17 BY A DEALERSHIP AT 46,000 MILES
BRAKES FAILED WHILE DRIVING DOWN A HILL IN 2ND GEAR.
2015 CHEVROLET CITY EXPRESS. CONSUMER WRITES IN REGARDS TO VEHICLE TIRES ISSUE. CONSUMER HAS PREVIOUS COMPLAINTS WITH DIFFERENT VEHICLES LISTED IN ARTEMIS. *SMD THE CONSUMER STATED THE TIRES WERE WEARING OUT ON THE INSIDE AND OUTSIDE EDGES PREMATURELY. THE ALIGNMENT WAS CHECKED AND IT WAS WITHIN THE RECOMMENDED SPECIFICATIONS. *JB
2015 Chevrolet Express: questions owners ask
Is the 2015 Chevrolet Express reliable?
NHTSA data alone cannot rate reliability, but it shows what owners reported. Owners filed 9 complaints with NHTSA about the 2015 Chevrolet Express; the most common categories were electrical system (2, 22.2%), latches/locks/linkages (2, 22.2%), service brakes (2, 22.2%). There are no safety recalls listed for this model year.
What are the most common problems with the 2015 Chevrolet Express?
Across 9 owner complaints filed with NHTSA, the categories mentioned most often are electrical system (22.2% of complaints), latches/locks/linkages (22.2% of complaints), service brakes (22.2% of complaints), suspension (22.2% of complaints), electronic stability control (esc) (11.1% of complaints). One complaint can name several components.
Does the 2015 Chevrolet Express have any recalls?
As of October 2026, NHTSA lists no safety recalls for the 2015 Chevrolet Express. Recalls can be issued at any time, so check your VIN at nhtsa.gov/recalls.
Check your own Express
Counts are a starting point, not a verdict: popular models collect more complaints because more of them are on the road, and NHTSA does not verify individual reports. To see whether a recall is still open on your car, enter your VIN at nhtsa.gov/recalls (U.S.) or your registration at check-vehicle-recalls.service.gov.uk (UK). Had a safety problem? Report it to NHTSA; complaints are what trigger investigations and recalls.
Data: NHTSA Office of Defects Investigation recall and complaint databases (public domain), retrieved October 25, 2026. Model year 2015 only; combines NHTSA's entries for EXPRESS CARGO G23405, EXPRESS CARGO G23705, EXPRESS CARGO G33405, EXPRESS CARGO G33705, EXPRESS PASSENGER 2500, EXPRESS PASSENGER 3500 12 PASS and EXPRESS PASSENGER 3500 15 PASS.