Problem Lookup › Chevrolet › Express › 2016
Car problem report
2016 Chevrolet Express problems, recalls and owner complaints
What the 2016 Chevrolet Express has been recalled for and what owners report, from official government data. Updated October 25, 2026.
- 0safety recalls
- 22owner complaints
- 1crash report
- 2fire reports
- 0injuries reported
22 complaints, against an average of 14 for the other 12 Chevrolet Express model years.
Every Chevrolet Express model year with its number of owner complaints. Pick a year to compare.
What goes wrong with the 2016 Chevrolet Express?
The components named most often in the 22 owner complaints. One complaint can name several, so the shares can add up to more than 100%.
Has the 2016 Chevrolet Express been recalled?
NHTSA lists no safety recalls for the 2016 Chevrolet Express as of October 25, 2026. Recalls can be issued at any time, so check your VIN before you rely on this.
What do 2016 Chevrolet Express owners report?
12 of the 22 complaints, the most recent for the most-reported components, as the owners wrote them. NHTSA removes names and VINs; long reports are trimmed. CarHooq has not verified individual claims.
The contact owns a 2016 Chevrolet Express. The contact stated while driving 65 MPH, the “Service Engine” warning light flashed on and off. The contact stated that after arriving to the residence and shifting into reverse(R), the vehicle failed to respond as needed. The vehicle was turned off and restarted and the contact was able to park the vehicle. The vehicle was later towed to the dealer to be diagnosed. The contact was informed that the Progressive Snapshot device had caused the failure. The vehicle was repaired, and the Snapshot device was removed; however, the failure persisted. The…
ABS Module Broken. Needs repair. No part available. Part Number 84055065 needed. Vehicle was on highway slowed on to onramp when ABS went off for no reason. Van Pulled to right drastically.
I'd be driving down the street when my brakes would apply by them selves slowing my car down . after that my dash would bong and the ABS light would come on . I took it to my Chevy dealer and they replaced the brakes and said it was fixed . I pulled out of the dealers lot and was driving at 35MPH when the brakes locked and a skidded to a stop . If I hadn;t been buckled in I would have gone thru the windshield . I held the gas pedal to the floor and returnd to the dealer at about 20 MPH and some salesman came running out and said my van was on fire .I got out of my van but I didn't see any fire…
AT 54,000 MILES, NOTICED 2-3 INCHES IN PLAY IN THE STEERING WILE DRIVING THE VEHICLE. NOW THAT THE STEERING HAS LOOSENED, IT IS A CONTINUAL ISSUE. I HAVE NOT HAD IT DIAGNOSED YET. HOWEVER, IN READING OTHER COMPLAINTS ON THIS SITE, THIS SEEMS TO BE A DESIGN ERROR. AS THIS IS DANGEROUS. THE NHTSA SHOULD FORCE GM TO ISSUE A RECALL.
PROBLEM: POWER WINDOW WOULDN'T WORK, REAR DEFROSTER WOULD NOT WORK, VEHICLE WOULD NOT START, VEHICLE WOULD CRANK BUT NOT START. CAR HAD TO BE TOWED. THE RELAYS WERE DEFECTIVE AND WERE REPLACED. UPON TAKING THE RELAYS APART , I FOUND THAT THEY WERE RUSTED INSIDE AND THE RUST WAS FLAKING OFF. I CONTACTED CHEVROLET AND I WAS TOLD THE VEHICLE WAS OUT OF WARRANTY AND IT WOULD NOT COVER RUSTED PARTS.THE REPRESENTATIVE ALSO SAID THAT HE HAD OTHER COMPLAINTS ABOUT THE RELAYS FAILING.THERE ARE TEN OF THESE RELAYS IN THIS VEHICLE AND FOUR HAVE FAILED DUE TO RUST. THERE IS NO WAY TO TEST THE REMAINING…
2016 SILVERADO DURAMAX. CONSUMER WRITES IN REGARDS TO CP4 FAILURE. *LD *JS
I REPORTED TO MY DEALER CHARPER CHEVROLET NOV. 2018,I HAD ROUGHLY 23K MILES,THAT MY 2016 CHEVY 3500 HAD DEVELOPED A WOBBLE, SHAKE WHATEVER YOU COULD CALL IT. THEY INVESTIGATED AND TOLD ME MY TIRES POSSIBLY HAD BROKEN BELTS THE TIRES HAD PLENTY OF TREAD LEFT. I WAS TOLD IF I COULD DEAL WITH THE SHAKE TILL I GET NEW TIRES SO BE IT. I RODE THEM TILL JULY 2019 GOT 6 NEW MICHELIN 235/80/17 LTX A/T2 TIRE PACKAGE. THEY RODE OK STILL HAD A LITTLE SHAKE TO START THEN IT GOT WORSE THE MORE I DROVE. LET ME SAY IT NEVER SHOOK ALL THE TIME IT WOULD COME AND GO. SOMETIMES WHEN I HEADED FOR WORK IN THE…
TL* THE CONTACT OWNS A 2016 CHEVROLET EXPRESS. THE CONTACT STATED THAT WATER WAS LEAKING FROM THE DRIVER'S SIDE VISOR CONNECTION. WATER ALSO LEAKED ONTO THE CONTACT AND THE FLOOR. THE INSTRUMENT PANEL WAS ALSO LEAKING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO SAWYER CHEVROLET (351 W BRIDGE ST, CATSKILL, NY 12414, (518) 291-4586) WHERE IT WAS DIAGNOSED THAT A NEW WI-FI ANTENNA GASKET NEEDED TO BE INSTALLED. THE VEHICLE WAS REPAIRED, BUT FAILED AGAIN DAYS LATER. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 36,000.
TL* THE CONTACT OWNS A 2016 CHEVROLET EXPRESS. UPON STARTING THE VEHICLE, THE SERVICE THEFT DETERRENT SYSTEM WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO HAYWARD MITSUBISHI (25601 MISSION BLVD, HAYWARD, CA 94544, (510) 999-5999) AND THE CONTACT WAS INFORMED THAT THE IGNITION KEY COULD BE THE CAUSE OF THE FAILURE. THE VEHICLE WAS REPAIRED, BUT THE CONTACT WAS UNAWARE OF THE REPAIRS THAT WERE COMPLETED. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL DAYS LATER. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO AGAIN STATED THAT THE FAILURE COULD BE THE IGNITION KEY; THEREFORE, A NEW…
UPON INSPECTION, IT WAS NOTICED THAT THE UPPER CONTROL ARM ON THIS AMBULANCE WAS CRACKED WHERE THE TOP OF THE COIL SPRING RESTS.THIS IS ON THE DRIVERS SIDE. THERE ARE CHUNKS OF THE CRADLE MISSING .WE HAVE TAKEN THIS VEHICLE OUT OF SERVICE. THE RIGHT SIDE CRADLE SHOWS NO CRACKING OR FATIGUE.
TL* THE CONTACT OWNS A 2016 CHEVROLET EXPRESS. WHILE THE VEHICLE WAS BEING OPERATED AT 55 MPH, THE VEHICLE STALLED AND THERE WAS AN ABNORMAL FUEL ODOR. THE FAILURE OCCURRED WITHOUT WARNING. UPON INSPECTION, IT WAS NOTICED THAT THERE WAS A FUEL LEAK. THE VEHICLE WAS TOWED TO A TOW TRUCK LOT. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 1,000. UPDATED 10/21/16*LJ THE CONSUMER STATED THE FUEL LINE SEPARATED, DUE TO A MISSING RETAINING CLIP. ALSO, TWO BRACKETS THAT WERE SUPPOSE TO ATTACH TO THE FUEL LINE WERE…
TL* THE CONTACT OWNS A 2016 CHEVROLET EXPRESS. THE CONTACT STATED THAT WHEN THE VEHICLE WAS PARKED ON AN INCLINE AND THE SLIDING DOOR WAS OPENED, THERE WAS NO LOCKING MECHANISM TO PROHIBIT THE SLIDING DOOR FROM CLOSING INDEPENDENTLY. THE CONTACT STATED THAT ON SEVERAL OCCASIONS THE DOOR CLOSED INDEPENDENTLY WHILE AN EMPLOYEE WAS MAKING DELIVERIES WITH THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS INFORMED BY THE GENERAL MOTORS FLEET COORDINATOR THAT THE VEHICLE WAS OPERATING AS INTENDED. THE APPROXIMATE FAILURE MILEAGE WAS 300.
2016 Chevrolet Express: questions owners ask
Is the 2016 Chevrolet Express reliable?
NHTSA data alone cannot rate reliability, but it shows what owners reported. Owners filed 22 complaints with NHTSA about the 2016 Chevrolet Express; the most common categories were service brakes (4, 18.2%), electrical system (3, 13.6%), structure (3, 13.6%). There are no safety recalls listed for this model year. 1 complaint mentions a crash, 2 mention a fire.
What are the most common problems with the 2016 Chevrolet Express?
Across 22 owner complaints filed with NHTSA, the categories mentioned most often are service brakes (18.2% of complaints), electrical system (13.6% of complaints), structure (13.6% of complaints), suspension (13.6% of complaints), engine (9.1% of complaints). One complaint can name several components.
Does the 2016 Chevrolet Express have any recalls?
As of October 2026, NHTSA lists no safety recalls for the 2016 Chevrolet Express. Recalls can be issued at any time, so check your VIN at nhtsa.gov/recalls.
Check your own Express
Counts are a starting point, not a verdict: popular models collect more complaints because more of them are on the road, and NHTSA does not verify individual reports. To see whether a recall is still open on your car, enter your VIN at nhtsa.gov/recalls (U.S.) or your registration at check-vehicle-recalls.service.gov.uk (UK). Had a safety problem? Report it to NHTSA; complaints are what trigger investigations and recalls.
Data: NHTSA Office of Defects Investigation recall and complaint databases (public domain), retrieved October 25, 2026. Model year 2016 only; combines NHTSA's entries for EXPRESS 4500, EXPRESS CARGO G23405, EXPRESS CARGO G23705, EXPRESS CARGO G33405, EXPRESS CARGO G33705, EXPRESS PASSENGER 2500, EXPRESS PASSENGER 3500 12 PASS and EXPRESS PASSENGER 3500 15 PASS.