2025 Chevrolet Suburban problems, recalls and owner complaints

driving down i30 at 70MPH and the rear passenger window exploded on my 10 year old child.

Valve spring broke at approximately 5200 miles. Dealer replaced the head.

The contact owns a 2025 Chevrolet Suburban. The contact stated that while driving approximately 65 MPH, a banging noise was heard coming from the engine compartment, and the vehicle decelerated. In addition, several warning lights, including the check engine light and the anti-lock braking system light illuminated. The contact pulled over to the side of the road, turned off the vehicle, and had the vehicle towed to a dealer. The dealer diagnosed that the engine and radiator failed and needed to be replaced. The engine and radiator were replaced. Approximately 5 months and 6,000 miles later…

3.0 Duramax engine failure at 5900 miles. Apparently is from the known thrust bearing issue. MIL, CEL, TCM illuminated. Failure occurred at 60 mph during rush hour traffic. Engine is being replaced under warranty. GM should issue recall for the affected lot of this engine.

2025 CHEVROLET SUBURBAN HIGH COUNTRY. Vehicle is parked in my garage. Went out in the AM and the engine only cranks, will not start. Called On Star for roadside assistance. Sent a tow truck, the vehicle could not be towed due to the electronic transmission. There is no way for an owner to place the transmission in neutral. Vehicle is stuck in my garage. GM customer service referred me back to roadside assistance who for the second time stated that they could not help me. This is a serious issue. The fact that the transmission can NOT be shifted into neutral unless the engine is running is a…

Car was parked (in covered area) when back window shattered sometime after 12pm. Car had not been driven in two days and outdoor temperature started at 62 that morning so there were not extreme temperature changes as at the time the window shattered, it was approximately 75 degrees. No apparent reason for breakage as we live in a secluded area and were nearby outside enjoying the day.

Purchased a brand new vehicle on 23Dec2025 (evening) and then drove it home and parked it in my garage. Vehicle was in my garage at 64 miles on the odometer. Vehicle started smoking and the transmission cooler line had the catastrophic failure spilling oil all over the street, driveway, and garage. It was towed from my garage to the selling dealer (Walser Polar Chevrolet in White Bear Lake, MN) on 24Dec2025. Service center confirmed a manufacturing defect in the transmission cooler line from the factory.

My rear passenger door flys open while driving. It happens during very cold weather. It also will not latch when trying to shut it after getting off the road and trying to shut it. My daughter has been in the seat next to the door each time and it has happened multiple times. Betten Chevrolet has tried to fix it twice and it is currently in their shop. This is totally unsafe!

Engine failed going 70mph on highway at 2k miles. Display said acceleration no longer available and app said transmission code was needing to be checked however once taking to dealer I was told it was an oil sensor then told there was shredded metal in my engine and I needed a full engine replacement. My car was in the dealership for over 50 days. I was pregnant and with two small children in the car when engine failed at high speeds. After my car was returned to me the engine overheated and failed again. The dealer claimed GM sent them an engine with cut hoses. I was 9 months pregnant when…

7/13/25: Car repeatedly jerking/shuddering/rough ride. A flashing check engine light came on for 10 or 15 minutes. After stopping car and restarting it, the check engine light went off. 9/15/25: Car jerking and another flashing check engine light. Took to dealership. They drove it and said no codes stored. Told it was probably the transmission "breaking in." Took home. Car continued to jerk/stumble. 8/28/25 to 9/15/25: Car jerking and flashing check engine light back on. Took to Autozone. A Random/Multiple Cylinder Misfire Code was detected (P0300). Took to dealership and confirmed P0300 Code…

My Onstar system is not working properly. I first noticed the Forward Collision light then the Wifi hotspot features not working. Reached out to onstar they couldn’t help then referred to dealership. Visited dealership 8/12/2025 was told there’s no error code although they see what’s happening. Doing further investigation of my own i found out this is a very well known issue amongst General Motors, Onstar and the dealerships selling these vehicles. There are varying issues customers are having from wifi not working to vehicles completely shutting down in traffic. Once my visit to the…

OnStar Module factory defaults/Malfunctioning - Power button don’t turn on so there’s no internet connection. This effect all the safety features in the car. Please recall. There has been numerous incidents reported online to this particular default.