2025 Ford Bronco Sport problems, recalls and owner complaints

On about 5 or 6 occasions over the course of one year, my brand new 2025 Ford Bronco Sport with the Big Bend trim with the VIN number in this report has completely lost engine power with severe engine hesitation with a highly rhythmic / even-patterned computer-controlled-like clicking and severe engine shaking (!!!) and a near stall while traveling from anywhere between 5 and 50 mph and the speed grinds down to a crawl, because it most often happens on an incline (maybe once on flat ground, and never downhill), and either way can be extremely dangerous! Fuel tank was full or half full on every…

Vehicle was taken to Bowen [XXX] ([XXX]) for a transmission rebuild under RO #XXX, following repeated transmission failures. Dealer performed a complete teardown and rebuild of the transmission (replacing clutch components, seals, gaskets, fluid, reprogramming solenoids), and the repair order states the vehicle was road tested after repair with no DTCs present and "operating as designed." Vehicle was picked up on XXX at 11:20 AM. Approximately 24 hours later, on XXX at approximately 3:49 PM, while the vehicle was stationary, the instrument cluster displayed a "Shift System Fault, Service…

The contact owns a 2025 Ford Bronco Sport. The contact stated that while driving at low speeds, the vehicle hesitated while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was taken to the dealer, where the failure could not be duplicated. Upon returning to the residence, the contact received notification of NHTSA Campaign Number: 26V122000 (Engine and Engine Cooling). The vehicle was taken back to the dealer, where the recall repair was performed; however, the failure returned two days after the repair. The failure continued for several weeks, and the…

The contact owns a 2025 Ford Bronco Sport. The contact stated that while driving downhill on the freeway with the adaptive cruise control engaged, the transmission independently shifted into neutral, the vehicle lost power, and failed to accelerate as needed. The vehicle was pulled over to the side of the road and shifted back into drive. The contact exited the freeway, and the vehicle was towed to a dealer. The contact stated that the word “CANCEL” in orange was displayed on the instrument panel, and the vehicle went into LIMP Mode. The dealer was unable to duplicate the failure. The vehicle…

1. The Electronic Power Assisted Steering (EPAS) module and/or the front passenger-side suspension components failed, causing a complete loss of steering control and an un-commanded, continuous violent pull to the right. Yes, the vehicle and all malfunctioning components are completely intact and available for immediate inspection upon request. 2. Safety was put at extreme risk during highway speeds. The vehicle violently and continuously swerved directly toward the right-hand passenger side. There were 5 total occupants in the SUV, including my daughter-in-law and my three young…

The car breaks without warning until it’s already hit them when no one is behind us as we’re backing up it just hits the breaks.

The contact owned a 2025 Ford Bronco Sport. While the contact’s brother-in-law was driving approximately 55 MPH, the vehicle crashed into the rear of another vehicle, causing the vehicle to flip over and slide between 50 and 75 yards. During the crash, the Forward Collision Avoidance system failed to activate, and the front driver’s side air bags did not deploy. The driver was later taken to the hospital and treated for a concussion and arm and leg abrasions. A Police report was filed at the scene, and the vehicle was towed away and later deemed a total loss by the insurance company. The cause…

This is a fourth occurrence related to NHTSA complaints 11749893, 11750183, and 11751201. The vehicle was previously diagnosed and repaired under warranty for the same 'Shift System Fault: Service Required' condition (transmission main control valve body replacement, RO #609213, completed July 21, 2026). Approximately 14 hours after pickup, on July 22, 2026, the identical fault recurred, the Check Engine light illuminated, and the vehicle died while driving. The vehicle was towed to Bowen Scarff Ford in Kent, WA and checked in the same day (RO #609522) for further diagnosis. This is now the…

This is a third occurrence related to NHTSA complaints 11749893 and 11750183. On July 15, 2026, at approximately 7:30-7:42 AM, while driving to a scheduled Ford service appointment, the vehicle exhibited hesitation and delayed acceleration at multiple intersections, not isolated to one location. Although the vehicle's auto start-stop feature has been manually disabled, the hesitation at each stop felt similar to that feature engaging and re-engaging the engine. The vehicle then stalled completely at an intersection and would not move for approximately 10 minutes. The check engine light…

I was in a car accident on the front/side of the drivers side of our ford Bronco sport. The steering wheel airbag did not deploy. But all other side airbags did.

Every morning when I back out of my driveway the brakes squeel as if the wear pad indicators have reached end of life. I took this to the dealer and they said this is completely normal

Traveling on I5 SB, near Longview, WA. Vehicle steering whell was jerked from my hands. I blacked out briefly from side window impact. Vehicle rolled over into trees and bushes next to the freeway. When I was able to finally see the vehicle at the tow yard. The Right front wheel assy, had seperated from the vehicle and was placed in the rear area of the vehicle. It had been sheared off in the accident. That is why I suspect a DEFECT. This vehicle line has been cited in several mishaps associated with steering issues, and a recall has been issued.