2016 Ford Expedition problems, recalls and owner complaints

The contact owns a 2016 Ford Expedition. The contact stated that while attempting to reverse, the rearview camera became inoperable. The contact stated that the rearview camera would occasionally display a blank screen, while at other times a "Camera Not Available" warning message was displayed. The vehicle was taken to multiple dealers, where it was diagnosed that the rearview camera had failed and needed to be replaced. The rearview camera was replaced; however, the failure recurred. The contact stated that the rearview camera failure persisted after an unknown recall repair associated with…

My 2016 Expedition has the same 6R80 transmission as the Ford F150, for which there is a recall for the Lead Frame. My wife was driving the vehicle on the highway and the check engine light came on and the vehicle went into "limp mode" causing the vehicle to decelerate to approximately 35 mph. Needless to say, she almost caused several accidents as she tried to move to the shoulder at a very reduced speed. The code was P0715 and P0717 which is the Turbine Shaft Speed Sensor which is part of the lead frame in the transmission. As stated before, there was a recall on this issue with the F150 but…

The contact owns a 2016 Ford Expedition. The contact stated that the blower motor functioned intermittently, turning on and off unexpectedly. The contact stated that the A/C functioned as intended during the cooler months but was intermittently inoperable in the warmer months, requiring that the wires that were overheating be repaired. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 22V648000 (Visibility, Electrical System); however, the recall repair failed to fix the issue. The dealer was notified of the failure, but the vehicle was not diagnosed or…

I am filing this complaint regarding an unresolved and potentially dangerous safety defect involving the rearview camera system on my Ford vehicle, which was presented to Wade Ford Auto Dealership and Service in Smyrna, Georgia for a rear camera recall repair. I brought my vehicle, a 2016 Ford Expedition, to Wade Ford for recall service related to the rearview camera. Wade Ford retained my vehicle for approximately one week. When I picked up the vehicle on or about [insert pickup date], I discovered that the rear camera issue had not been corrected. The rear camera image remains dark, unclear…

My expedition started stuttering and the speedometer, started fluctuating speeds which would also cause my cruise control to turn off. Then the speedometer quit working altogether and so did the odometer. If I turned the truck off and restarted it, it would reset everything for a few miles then it would start all over again. I went to the Ford dealership and got it fixed. It cost 2500. Later doing research, I discovered this is a problem with this transmission and can be very dangerous as the truck can downshift dramatically which our did once. If I’ve been on ice or pulling my trailer, it…

The failed components are called "cam phasers." It is a known problem with the Ford 3.5 Ecoboost Engine (that even Ford is aware of). The cam phasers can fail, causing the timing chain to fail at any moment. They rattle upon startup of a cold engine. The failure of the original engineering is causing owners of this vehicle, along with the F150 and others, to have to spend anywhere from $3,000 to $5,000 in order to replace these. The problem has been confirmed by the Ford dealer. In order to visually examine the cam phasers, it requires something like 10+ hours to open the engine. You do not…

When merging on the highway in the rain the vehicle locked up on me and almost killed me. I could have been seriously injured I could not stop the car and it slid along the highway at high speeds . Luckily was able to get to the shoulder

The vehicle stops accelerating randomly it’s been in the shop (Ford dealer) a few times and they are unable to pinpoint the issue. The warning lamps would come on after the vehicle fails to accelerate. It would lose power at any interval and coast until it’s fully stopped.

while driving on the highway my vehicle shut down and service lamp came on and while drifting tried to put transmission in neutral and restart but had to come to complete stop to restart engine in park. I was in third lane and had no warning before shut down and could not get to the shoulder. (almost got hit trying). I reported to the dealer and they said there was no fault codes stored. I was driving to work on a 4 lane street a week later and again it shut down without previous warning again and had to crash up onto the curb to get off street to again restart in park. dealer said again no…

The contact owns a 2016 Ford Expedition. The contact stated that while starting the vehicle, a burning odor was detected. The contact later received notification of NHTSA Campaign Numbers: 22V150000 (Service Brakes, Hydraulic) and 22V648000 (Visibility, Electrical System). The vehicle was taken to the dealer, where it was diagnosed that the front blower motor connector and resistor needed to be replaced; however, the parts were not covered under the recall. The vehicle was not repaired. The contact stated that the front blower motor connector was previously replaced; however, the failure…

The contact owns a 2016 Ford Expedition. The contact stated while driving 15 MPH, the brake pedal was depressed; however, the vehicle failed to stop immediately. The contact activated the parking brake to stop the vehicle. The vehicle was previously repaired under NHTSA Campaign Number: 22V150000 (Service Brakes, Hydraulic). The vehicle was taken to an independent mechanic, who diagnosed the vehicle with brake master cylinder and brake booster failure. The vehicle was then taken to a dealer, where it was diagnosed with hydraulic control unit failure. The manufacturer was made aware of the…

Wife driving 2016 Ford Exped with 61000 miles. Was driving on a remote road when the vehicle suddenly lost power and power train fault indicator came on. No cell service and no other traffic so no way to get help. Finally managed to restart which cleared the problem for now. Took the car to a Ford dealer immediately but code reader could find no fault. Dealer, however, said it is a throttle body malfunction and is not uncommon and will happen again. Now concerned about problem occurring on a freeway or other congested roadway. The sudden loss of power and resulting necessity to get off a busy…