2012 Ford F-450 problems, recalls and owner complaints

KEY IN IGNITION CIRCUIT IS OPEN - ENGINE LIGHT ON ' FIXD INDICATES INSPECTION ISSUE.

WE HAVE TO REPLACE OUR FUEL TANK BECAUSE THE LINING HAS DELAMINATED. WE HAVE ALREADY HAD TO REPLACE THE ENGINE WHICH MAY HAVE BEEN A RESULT OF THE LINING DETERIORATION.

TL* THE CONTACT OWNS A 2012 FORD F-450. WHILE DRIVING 40 MPH, THE VEHICLE BEGAN TO STALL AND THE CHECK ENGINE AND OIL PRESSURE WARNING INDICATORS ILLUMINATED. THE CONTACT WAS ABLE TO PARK THE VEHICLE ON THE SIDE OF THE ROAD AS IT STALLED AND TURNED OFF. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND THEN TO BAYSHORE FORD TRUCK SALES (LOCATED AT 4003 N DUPONT HWY, NEW CASTLE, DE 19720, (302) 656-3160) WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 38,500.

THE A/C COMPRESSOR JUST WENT OUT FOR THE SECOND TIME AND FROM WHAT IT LOOKS TO ME IS WHY THE SECOND FAILURE HAS OCCURRED IS BECAUSE THE DEALERSHIP DID NOT REPLACE THE CONDENSER AS WAS REQUIRED AND ALSO PAID FOR BY ME. THE TRUCK HAS THE "DEATH-WOBBLE" EVEN THOUGH I HAVE REINFORCED THE STEERING IN GENERAL AND IS VERY DANGEROUS. HOWEVER, DUE TO JUST THESE TWO ISSUES AND THE OTHERS IT HAS HAD WHICH ARE FAILED WATER PUMP, TURBO, STARTER AND HYDRO-BOOST BRAKE BOOSTER WITH THE WATER PUMP GOING OUT AT ABOUT 50,000 MILES AND THEN THE TURBO AT ABOUT 82,000 MILES WITH THE WORK PERFORMED AT TWO DIFFERENT…

I TOOK MY FORD F-450 LARIAT FOR ITS 60,000 MILES SERVICE. AFTER THE SERVICE WAS DONE, WHILE DRIVING IT HOME FROM THE FORD DEALERSHIP (AUTONATION FORD IN CORPUS CHRISTI, TX), ON THE FREEWAY AS SOON AS I GOT TO AROUND 50 MILES PER HOUR THE VEHICLE'S FRONT STARTED TO SHAKE/WOBBLE VERY VIOLENTLY. SPEEDING UP TO THE SPEED LIMIT (60 MPH) DID NOT HELP AND THE SHAKING GOT ACTUALLY WORST, I HAD TO STOP FOR THE SHAKING/WOBBLING TO STOP, THANKFULLY I WAS STILL ON THE RIGHT LANE AND THERE WAS A WIDE ENOUGH SHOULDER FOR ME TO STOP. AS SOON AS I RESTARTED AND GOT TO ABOUT 50 MPH THE VIOLENT SHAKING…

WHILE DRIVING DOWN A PARKWAY AT THE SPEED LIMIT, WE TRAVELED OVER SEVERAL BRIDGES AND ALL OF A SUDDEN AFTER HITTING A ROUGH SPOT IN THE ROAD AND OVER THE BRIDGES THE TRUCK BEGAN TO SHAKE VIOLENTLY AND WE HAD TO ALMOST COME TO A STOP TO HOLD IT IN THE ROAD. IT CONTINUED TO DO THIS ALMOST EVERY TIME WE HIT A BUMP IN THE ROAD. WE HAD JUST RECENTLY BOUGHT THIS TRUCK USED, I AM SCARED TO RIDE OR DRIVE THIS TRUCK ANYMORE, IT IS MY HUSBANDS AND HE DOES. WE PULL A HORSE TRAILER AT TIMES AND I AM SCARED TO DO SO BECAUSE IT PUTS OUR LIVES AS WELL AS OTHER MOTORISTS LIVES AND MY HORSES IN DANGER. THIS…

DRIVING DOWN THE HIGHWAY IN THE RAIN TRUCK STARTED SHAKING COULD NOT HOLD STEERING WHEEL . TRUCK STARTED GOING SIDEWAYS ON HIGHWAY FROM SHAKING/ WOBBLE. TRUCK SHUTS OFF DRIVING DOWN THE ROAD WITH NO WARNING NO STEERING OR BRAKES TOWING EQUIPMENT. I HAVE HAD MY 1 YEAR OLD DAUGHTER IN TRUCK ALMOST IN A ACCIDENT 2 TIMES NOW FROM TRUCKS DEATH WOBBLE AND MOTOR SHUTTING OFF TOWING EQUIPMENT.

I WAS DRIVING ALONG MY 2012 FORD F450SUPERDUTY TURBO DIESEL ALONG THE INTERSTATE 495 DC BELTWAY IN MARYLAND WITH MY SEVEN YEAR OLD SON IN THE BACK SEAT, WHEN A LCD IN THE MIDDLE OF THE SPEEDOMETER GAVE A WARNING WHICH READ "REDUCED POWER" AND COULD IMMEDIATELY FEEL A REDUCED RESPONSIVENESS OF THE TRUCK TO THE ACCELERATOR. A MOMENT LATER ANOTHER SIGN READ " CLEANING EXHAUST FILTER" WHICH DISAPPEARED ALMOST IMMEDIATELY. A MOMENT LATER A FINAL WARNING CAME UP WHICH READ" STOP AT A SAFE LOCATION. I BEARLY PULLED OVER TO A DANGEROUS SHOULDER WHEN MY TRUCK SHOT DOWN. AT THIS POINT I COULD NO LONGER…

AS PER YOUR ODI RESUME #RQ14-005, MY RV BUILT ON 2012 CHASSIS EXPERIENCED EGT SENSOR MALFUNCTION TO NUMBER 13 AND 14. THIS OCCURRED ON I-75 OUTSIDE OF LEXINGTON, KY. I WAS VERY LUCKY TO BE IN THE RIGHT LANE AND JUST BARELY PULLED TO THE SHOULDER BEFORE THE ENGINE SHUTDOWN. HAD TO CALL STATE POLICE BECAUSE OF THE CLOSE PROXIMITY TO TRAVEL LANE AND VERY DANGEROUS SITUATION FOR OTHER VEHICLES. THIS TRIP STARTED IN CLEMMONS, NC, AND INCLUDED 2 TUNNELS WHICH COULD HAVE BEEN A DISASTER IF THE INCIDENT OCCURRED IN EITHER ONE. CALLED FORD ABOUT RECALL FOR AMBULANCE CHASSIS SINCE THIS SEEMS TO BE SAME…

VEHICLE WAS INITIALLY NOT RUNNING AND IN DRIVEWAY. THERE HAD BEEN NO PRIOR INDICATION OF ANY PROBLEM, AND NO ISSUE NOTED WITH ON-BOARD DIAGNOSTIC SYSTEM. VEHICLE HAD RECENTLY BEEN SERVICED AT LOCAL FORD DEALER FOR OIL/FILTER CHANGE. DEALER INSPECTION NOTED NO ISSUES WITH THE VEHICLE. VEHICLE WAS CRANKED UP AND PUT INTO DRIVE. VEHICLE EXPERIENCED A SUDDEN, IMMEDIATE, AND TOTAL LOSS OF POWER STEERING AND BRAKE CAPABILITY. VEHICLE LURCHED FORWARD. EXTREME PRESSURE WAS APPLIED TO BRAKE PEDAL BUT IT WOULD NOT STOP VEHICLE FROM MOVING FORWARD. POWER STEERING WAS NON-FUNCTIONAL CAUSING EXTREME…

THIS VEHICLE IS AN AMBULANCE AND WAS DISPATCHED ON AN EMERGENCY CALL. THE CREW ATTEMPTED TO CRANK THE VEHICLE, BUT THE STARTER WOULD NOT EVEN ENGAGE. ANOTHER AMBULANCE HAD TO BE DISPATCHED TO THE CALL. IT WAS LATER DETERMINED THAT ONE OF THE FOUR EGT EXHAUST GAS TEMPERATUR SENSORS HAD FAILED AND DISABLED THE VEHICLE. HAD THE VEHICLE BEEN TRAVELING ON THE HIGHWAY, A VERY DANGEROUS SITUATION COULD HAVE OCCURRED. THERE WAS NOT AN OVER HEATED EXHAUST CONDITION NOR AN EXHAUST EMISSION PROBLEM AT THE TIME, WHICH IS WHAT THESE SENSORS ARE DESIGNED TO DETECT. THE POWERTRAIN CONTROL MODULE(PCM) SHOULD…

THIS VEHICLE, WHICH IS AN AMBULANCE, WAS DISPATCHED TO AN EMERGENCY CALL. AS THEY TURNED INTO THE DRIVE OF THE FACILITY THE CHIMES SOUNDED AND THE ENGINE SHUT OFF. HAD THIS VEHICLE BEEN ON THE HIGHWAY AT THE TIME, IT WOULD HAVE BEEN A VERY DANGEROUS SITUATION FOR THE CREW INVOLVED. AT THE VERY LEAST, ANOTHER AMBULANCE HAD TO BE DISPATCHED TO THE CALL AND DELAYED CARE TO THE PATIENT. IT WAS DETERMINED LATER THAT THE EGT SENSOR HAD FAILED, ALTHOUGH THERE WAS APPARENTLY NO PROBLEM IN THE EXHAUST SYSTEM AT THE TIME.