Problem Lookup › GMC › Sierra › 2012
Car problem report
2012 GMC Sierra problems, recalls and owner complaints
What the 2012 GMC Sierra has been recalled for and what owners report, from official government data. Updated October 25, 2026.
- 4safety recalls
- 192owner complaints
- 9crash reports
- 2fire reports
- 6injuries reported
192 complaints, against an average of 506 for the other 14 GMC Sierra model years.
Every GMC Sierra model year with its number of owner complaints. Pick a year to compare.
What goes wrong with the 2012 GMC Sierra?
The components named most often in the 192 owner complaints. One complaint can name several, so the shares can add up to more than 100%.
What symptoms do 2012 GMC Sierra owners describe?
Found by reading the text of all 192 owner complaints. Tap a symptom for the answer, a real owner quote and any related recall.
Has the 2012 GMC Sierra been recalled?
4 U.S. safety recalls. Repairs are free at a franchised dealer; some are done over the air.
Air Bags: Frontal: Passenger Side: Inflator Module General Motors, LLC (GM) is recalling certain 2012 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Fix: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328770.
Air Bags: Frontal: Passenger Side: Inflator Module General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Fix: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.
Equipment General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Risk: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Fix: GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM's number for this recall is 18146.
Fuel System, Gasoline: Storage: Auxillary Tank General Motors LLC (GM) is recalling certain 2011-2015 Chevrolet Silverado 3500 and GMC Sierra 3500 trucks equipped with dual fuel tanks. The low fuel level sensor for the front tank may stick causing the rear tank to overfill the front tank.
Risk: If the front tank overfills, the excess pressure may cause the front tank to expand and contact the driveshaft, possibly resulting in a hole in the tank. The hole will leak fuel, which in the presence of an ignition source, can increase the risk of a fire.
Fix: GM has notified owners, and dealers will replace the rear tank fuel pump or update the fuel-level sensor software, as well as inspect the front tank, replacing it as necessary, free of charge. The recall began December 11, 2017. Owners may contact GM customer service for Chevrolet 1-800-222-1020 or for GMC customer service at 1-800-462-8782. GM's number for this recall is 17399.
Is the 2012 GMC Sierra recalled in the UK or Europe?
Recalls issued by the UK's DVSA and through the EU's Safety Gate system that cover this model and build period. European models can differ from U.S. ones, and "years estimated" means the recall gave no build dates, so confirm your own car with your registration or VIN.
EU Safety GateThe propellant used in the passenger-side frontal airbag inflator may experience a material alteration over time due to degradation…The propellant used in the passenger-side frontal airbag inflator may experience a material alteration over time due to degradation occurring after prolonged exposure to high absolute humidity, high temperatures and high-temperature cycling. In the event of an airbag being deployed, the excessive internal pressure may cause the inflator body to rupture and metal fragments may pass through the cushion material causing injury to the occupants.
Measures: Type of economic operator taking notified measure(s): Manufacturer; Category of measure(s): Recall of the product from end users; Date of entry into force: Unknown
What do 2012 GMC Sierra owners report?
12 of the 192 complaints, the most recent for the most-reported components, as the owners wrote them. NHTSA removes names and VINs; long reports are trimmed. CarHooq has not verified individual claims.
June 29, 2025, Driving on the St. Francis loop in Amarillo, TX, brake lights start flashing, the warning sounds happening, no brakes. I had already slowed down to 35-45 mph due to road construction ahead. I weaved through the cones and as soon as possible, hit the ditch and then coasted to a stop. (I didn’t think about the emergency brake, in my panic.) I turned the vehicle off and called my husband. I decided that I wasn’t pulled over far enough over in the ditch, so I started the pickup again. The lights and warning signals for the brakes were gone and when I pressed on the brake pedal…
They should be responsible for repairs or replacement of the cheap made frames that rust away so fast so u ain’t gotta worry about your truck fallling apart going down the rd and the lower control arms made of cast that rust from inside out and you don’t know until breaks while driving along with camber adjustments where they can throw alignment out with a single bump. Mostly the frame replacement is major always having to plate frame or check to make sure it will be able travel long trips or haul stuff in bed or a trailer with breaking or falling off truck causing wreck frame repair is major…
Our Dash board cracked very badly from the top next to the speaker to the passenger side air bag. We purposely use a dash board cover and never place heavy things on it. This is a safety issue as if getting in an accident wouldn’t be bad enough flying shrapnel would be worse. We just had it fixed at a dealership to the tune of $2500. This is not okay as I see this is a constant problem.
Odometer Fraud. The contact purchased a 2012 GMC Sierra 1500. The contact stated that it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the mileage was 111,000, and at the time of registration, it was discovered that the mileage was 243,000. The Carfax Report indicated that the vehicle was serviced at 149,000 and 179,000 miles, then registered at 149,000 and 179,000 miles on August 8, 2024. The contact had filed a police report with the Dillon Police Department -Special Ops Police Department.
P0521 has been addressed/replaced almost nine (9) times. “Low Oil Pressure-Stop Engine” is another one that is not completely functional. The truck is using oil but we cant find evidence of leakage. Services performed at dealership or certified shop. Troubleshooting was performed, Im told. I cant vouch for the quality of the workmanship. This should not be an issue at this mileage 100,100 ohe hundred thousand miles and oil components going bad is not good. GMC has sold me a truck that needs a new engine component. Please help. Thanks [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF…
The contact owns a 2012 GMC Sierra 2500. The contact received notification of NHTSA Campaign Number: 21V051000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer and an unknown dealer were contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect. .
Faulty Tire Pressure Management system. Looking for recalls or service bulletins.
Major major frame and wheel well rust , ever one I see is exactly the same , I live in upstate ny and yes we use salt but I've done a lot of research and the problem is country wide , please do some things this isn't right , I'm not trying to get a new free truck , just not get screwed out of the one I have cause it will fail inspection soon
I went to get the vehicle inspected today and was told it failed due to the chassis frame in the rear being rusted thru. This could cause the suspension to collapse any time. I see on the internet that multiple others have and are experiencing the same with the Sierra and Silverado. My vehicle has unlimited washes and has been washed 40 times a year and looks new from the outside.
Lifter Failure: I was traveling to a State Park in Northern Michigan when my engine starting running very rough with major power loss. My check engine light activated, and I pulled over as soon as I could. It was dangerous because I was pulling a camper and I had to drive well under the speed limit. The Certified Chevy Dealership discovered a collapsed lifter and Cam damage. They considered this as catastrophic engine failure, and I was completely shocked as the vehicle had roughly 129k miles on it. There was no indication of failure prior to this incident as the vehicle ran perfect. I am very…
Truck is a diesel. Fuel pump blew up and died in the middle of the street. Now I'm being told the Fuel system needs completely re done and will cost me 10g. I also found a lawsuit for this issue as well.
WHILE DRIVING THE TRUCK ON A COUNTRY ROAD, IT STARTED TO PULL TOWARDS THE RIGHT. I TRIED TO CORRECT BY STEERING TO THE LEFT. MY STEERING WHEEL JUST SPUN AND HAD NO CONTROL OF THE FRONT WHEELS. ITHE STEERING SHAFT BECAME DISENGAGE FROM THE AXEL. I CRASHED INTO TREES AND MY TRUCK WAS DECLARED A TOTAL LOSS. THIS HAPPENED ON 9/27/2020. I AM WAITING FOR THE POLICE REPORT AND THE INSPECTION RESULTS FROM THE INSURANCE COMPANY.
2012 GMC Sierra: questions owners ask
Is the 2012 GMC Sierra reliable?
NHTSA data alone cannot rate reliability, but it shows what owners reported. Owners filed 192 complaints with NHTSA about the 2012 GMC Sierra; the most common categories were air bags (57, 29.7%), structure (35, 18.2%), electrical system (22, 11.5%). There are 4 safety recalls. 9 complaints mention a crash, 2 mention a fire, 6 injuries were reported.
What are the most common problems with the 2012 GMC Sierra?
Across 192 owner complaints filed with NHTSA, the categories mentioned most often are air bags (29.7% of complaints), structure (18.2% of complaints), electrical system (11.5% of complaints), engine (9.4% of complaints), power train (7.8% of complaints). One complaint can name several components.
Does the 2012 GMC Sierra have any recalls?
Yes. NHTSA lists 4 recalls for the 2012 GMC Sierra; the most recent (campaign 21V051000, 2021-02-05) concerns Air Bags: Frontal: Passenger Side: Inflator Module. Recall repairs are free at a franchised dealer; check your VIN at nhtsa.gov/recalls.
Does the 2012 GMC Sierra have rust or paint problems?
10 of the 192 owner complaints NHTSA has on file for the 2012 GMC Sierra (5.2%) describe rust, corrosion or peeling paint. One owner wrote: "Major major frame and wheel well rust , ever one I see is exactly the same , I live in upstate ny and yes we use salt but I've done a lot of research and the problem is country wide , please do some things this isn't right , I'm not trying to get a new free…" (NHTSA complaint 11560212, December 2023). If it happens to your car, check your VIN for open recalls at nhtsa.gov/recalls and report the problem to NHTSA; complaints are what trigger investigations.
Why is the airbag light on in my 2012 GMC Sierra?
8 of the 192 owner complaints NHTSA has on file for the 2012 GMC Sierra (4.2%) describe airbag warning lights or airbag faults. 2 related recalls exist: campaign 21V051000 (air bags: frontal: passenger side: inflator module). The fix: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. One owner wrote: "Takata Recall. The contact owns a 2012 GMC Sierra 1500. The contact received notification of NHTSA Campaign Number: 21V054000 (Air Bags) however, the part to do the recall repair was not yet available." (NHTSA complaint 11419358, June 2021). Recall repairs are free at a dealer; check your VIN at nhtsa.gov/recalls.
Why does my 2012 GMC Sierra stall, lose power or shut off while driving?
7 of the 192 owner complaints NHTSA has on file for the 2012 GMC Sierra (3.6%) describe the engine stalling, losing power or shutting off while driving. One owner wrote: "Transmission surges when gas pedal is pushed hard as in trying to engage kickdown or "passing gear". speed is not a factor, it happens at low speed and higher speeds. depending on speed, truck jerks suddenly and almost stalls out." (NHTSA complaint 11349066, August 2020). If it happens to your car, check your VIN for open recalls at nhtsa.gov/recalls and report the problem to NHTSA; complaints are what trigger investigations.
Check your own Sierra
Counts are a starting point, not a verdict: popular models collect more complaints because more of them are on the road, and NHTSA does not verify individual reports. To see whether a recall is still open on your car, enter your VIN at nhtsa.gov/recalls (U.S.) or your registration at check-vehicle-recalls.service.gov.uk (UK). Had a safety problem? Report it to NHTSA; complaints are what trigger investigations and recalls.
Data: NHTSA Office of Defects Investigation recall and complaint databases (public domain), EU Safety Gate alerts (© European Union), retrieved October 25, 2026. Model year 2012 only; combines NHTSA's entries for SIERRA 1500, SIERRA 1500 HYBRID, SIERRA 2500 and SIERRA 3500.