Engine Misfire Detected on Startup (First 1000 Revolutions)

Ford issued TSB 22-2229 (and earlier TSB 19-2208) specifically covering 2018 2.0L EcoBoost engines with coolant intrusion into the cylinders. The Root Cause: Ford redesigned the engine block around mid-2019 because the original design allowed coolant to pool in small grooves between the cylinder bores, eventually degrading the head gasket or cracking the cylinder wall. Error code * P0316 — misfire detected during startup. Ford dealer estimate $12,700 for the Repair. A new engine block.. Ford customer care says there is no assistance available because the vehicle is out of warranty. It has 60,555 miles.

The component that has failed is the engine and it is available for inspection. The vehicle on multiple occasions has had loss of power while driving. The most recent incident was when I was driving 100 miles on interstate 81 and could not go more then 60 miles an hour. I had multiple semis and vehicles that had to go around me as the speed limit was 70. It also had severe loss of power going over mountains to go home. It also would shudder upon starting up and constantly lost antifreeze. I took the vehicle to Stuckey ford Bellefonte service shop and they confirmed coolant leaking into cylinder 2 and that it needed a new engine. They performed a multi-point vehicle inspection and a visual…

Capital Ford of Wilmington diagnosed my vehicle with coolant intrusion into cylinder 2, accompanied by diagnostic trouble codes P0302 and P0316, after check engine light came on. I have been advised that the vehicle requires a complete engine replacement, with an estimated cost of $13,180.89. The vehicle has experienced sputtering and hesitation, creating concern that it could lose power or stall. These symptoms are concerning. After researching this issue, I have learned that coolant intrusion is a documented problem associated with certain Ford vehicles equipped with the 1.5L EcoBoost engine produced during the 2017–2019 period. Ford has addressed this issue through Technical Service…

The 2.3L EcoBoost engine failed due to coolant leaking into the combustion chambers. The dealer found coolant present in cylinders 1 and 4, the cylinder 4 piston washed, and vertical scoring on the cylinder 4 wall. The dealer's recommendation is complete engine replacement. Yes, the engine is available for inspection. The vehicle is currently at the Ford dealership and the engine has not yet been replaced. Coolant entering the cylinders causes misfiring and loss of engine power. The vehicle shook on startup and ran roughly, and the misfire was intermittent and unpredictable. A sudden loss of motive power while driving in traffic or at highway speed is a crash risk to me and to other drivers…

Vehicle: 2021 Ford Explorer XLT - 2.3L EcoBoost I-4 VIN: [XXX] Odometer: 127,824 Date of failure: [XXX] Complaint Description: I am reporting a complete engine failure due to coolant intrusion on my 2021 Ford Explorer 2.3L EcoBoost. This is the known defect affecting 2016-2024 Explorer 2.3L engines. Independent shop diagnosis from attached receipt states: "Engine failure due to Head problem, which cylinder 3 + 4 and head in engine known for coolant intrusion. Cylinder Head failure, carbon build up plus Turbocharger also failure." Vehicle stored DTCs P0300, P0302, P0304, P0316 - random misfire and start-up misfire. Symptoms included rough idle on cold start, white smoke from exhaust, loss of…

This began in November of 2022 as an Intermittent concern. At first, it appeared that I could temporally correct by pulling over completely shutting off the truck and re-starting (re-booting) but is rapidly becoming worse and today (02/09/2023) became untenable, no matter what I did; the speedometer would not work or behaved erratically for brief periods; the information center display disappeared and then became dashes; the transmission randomly down-shits gears causing the wheels to lock up briefly or does not shift at all, causing engine RPMs to spike. While thankfully this has only occurred at speeds below 40 MPH, I feel that this is a safety concern for myself and others as operation of…

The component that failed is the CANISTER PURGE VALVE. The engine light was on and we took it to a certified auto shop. Report from the auto shop: Diagnosis for check engine lamp on, run tests for codes P0300 random misfire, P0316 misfire on startup, P1450 cannot bleed fuel tank vacuum. No misfires present at this time found sticking canister purge valve pulling a constant vacuum on the fuel tank, makes is possible to pull raw fuel if the fuel level is high, suspect this to be the cause of misfire codes. Recommendation by the auto shop: Replace canister purge valve, clear computer, and retest on cold start.

In Jan 2024 my car started running rough. In Feb 2024 I was mailed the 23V-905 recall notice. Late Feb I had the oil changed in my car. This didn't help the rough running. Mar 4 2024 a warning came on indicating "low engine oil pressure". I took it back to the oil change shop, who looked at everything, showed me it had a safe oil level...it was not dripping oil on my driveway. I was then told about the recall notice and to have it diagnosed at a dealership. Every dealer I called advised it an advance notice only, it's okay to drive my car, until parts are available - In July. I called Ford who gave me a service ticket CAS48387851. My dealership did a diagnosis and said there is metal in the…

Vehicle: 2023 Ford F650 7.3L Godzilla engine (VIN: [XXX] ) Issue: Catastrophic engine failure at 48,664 miles - camshaft/lifter failure requiring $21,898 repair Purchase: Feb 2024 with 6,250 miles (essentially new) Ford's Illegal Denial: Denying warranty coverage solely due to rebuilt title status Rebuilt title from cosmetic damage only - no engine/mechanical damage Engine defect completely unrelated to previous cosmetic damage Ford's Contradictory Actions: Simultaneously covers identical engine defects in A&M's 2022 F550 under Recall 24S78 Acknowledges 7.3L Godzilla manufacturing defects in Technical Service Bulletins Has 3,000+ warranty claims for related engine failures Legal Violations…

The contact owns a 2018 Land Rover Discovery Sport. The contact stated that while driving at an undisclosed speed, and while the vehicle was idling, there was an abnormal rattling sound coming from the vehicle. The vehicle lost motive power and the transmission failed to shift properly. The contact conducted was able to retrieve DTC: P1315, P0304, P0316, P054A and P0014. The dealer was not notified of the failure. The manufacturer was notified of the failure. The approximate failure mileage was 72,000.