Fuel Pump 'A' Control Circuit /Open

TL* THE CONTACT OWNS A 2015 FORD TAURUS. CONTACT STATED THAT AFTER PARKING THE VEHICLE, THEY ATTEMPTED TO RESTART THE VEHICLE HOWEVER, THE VEHICLE SHUDDERED AND STALLED. THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE RESIDENCE WHERE AN INDEPENDENT MECHANIC DIAGNOSED THE VEHICLE. THE DTC CODE WAS P0627 (FUEL PUMP FAILURE). THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE FAILURE WAS RELATED TO NHTSA CAMPAIGN NUMBER: 16V621000 (FUEL SYSTEM, GASOLINE), HOWEVER, THE VIN WAS NOT INCLUDED. THE CONTACT MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

SEVERAL STALLS FOLLOWED BY CRANK NO START CONDITIONS OVER SEVERAL MONTHS WITH NO ASSOCIATED CHECK ENGINE LIGHT, CODE P0627 WHILE VEHICLE IN MOTION. 4M AUTO SERVICE CENTER ABILENE TX PERFORMED FUSE 27 RELOCATION TO FUSE 73 ACCOMPLISHED. VEHICLE RETURNED TO SERVICE. SEVERAL STALLS FOLLOWED BY CRANK NO START CONDITIONS OVER SEVERAL MONTHS WITH NO ASSOCIATED CHECK ENGINE LIGHT, CODE P0627 WHILE VEHICLE IN MOTION. CODE CLEARED, VEHICLE RETURNED TO SERVICE. STALLED FOLLOWED BY CRANK NO START CONDITIONS WITH CHECK ENGINE LIGHT, CODES P025A, U0109 AND P0627 WHILE VEHICLE STATIONARY. 4M AUTO SERVICE CENTER ABILENE TX REPLACED FUEL PUMP CONTROL MODULE. VEHICLE RETURNED TO SERVICE. SEVERAL STALLS…

This is a continuation/escalation of NHTSA complaint 11689917. My 2021 Ford F-150 has experienced repeated fuel-system/electrical fuel-pump failures. The vehicle previously stalled and later cranked but would not start, returning code P0627 “Fuel Pump A Control Circuit / Open.” The in-tank fuel pump was replaced at owner expense for approximately $1,400 at an independent service center in September of 2025, but the repair did not permanently resolve the issue. The vehicle has now again lost fuel pressure/propulsion while traveling approximately 50 mph on a two-lane highway in a similar manner to prior failures. I was able to get the vehicle off the roadway, and it required towing back to my…

VEHICLE CRANKS BUT WON'T START. CODE READER READS P0627 FUEL PUMP CONTROL CIRCUIT OPEN. THE VEHICLE WAS IN MOTION AND THEN STOPPED. I HAD MY TANK ALMOST FULL.

VEHICLE LOST ALL POWER WHILE PULLING INTO A 4 WAY MAIN ROAD. VEHICLE EMERGENCY LIGHTS/FLASHERS DID NOT WORK. COMPLETE ELECTRICAL FAILURE. CAR WAS STALLED IN ACTIVE TRAFFIC LANE DURING NIGHT TIME HOURS. VEHICLE WAS TOWED INTO DEALER FOR FULL DIAGNOSTIC REVIEW- NO ISSUE WAS FOUND WITH VEHICLE, ALTHOUGH SEVERAL EEC TEST CODES WERE DETECTED- P0627, P0629, P01400, U18A2, U1524 AND U18B4+71- MOST CODES HAVING TO DO WITH FUEL PUMP/EMISSION ISSUES. OWNER OF VEHICLE CONSIDERS THIS A SERIOUS ISSUE AS CAR STALLED AT NIGHT, IN A HEAVY TRAFFIC AREA WITH NO LIGHTING OR EMERGENCY FLASHERS WORKING TO PROVIDE PROTECTION FROM ON-COMING TRAFFIC. EMERGENCY PERSONNEL WERE CALLED TO ASSIST.

The contact owns a 2021 Ford Expedition. The contact stated that while his wife was inside the vehicle with the vehicle idling, the vehicle vibrated and then turned off. The contact's wife attempted to restart the vehicle, but the vehicle failed to start. The vehicle was towed to the dealer, where it was diagnosed, and the dealer retrieved DTC: P0627; and informed the contact that the fuel pump had failed. The control unit and fuel pump were replaced. The contact referenced NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the VIN was not included in the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 74,000.

THE TRUCK SEEMED TO BE RUNNING OUT OF GAS, SURGED, SPUTTER, SURGE SPUTTERED THEN QUIT RUNNING. I HAD 1/2 A TANK. HAD TO COST THE TRUCK A CROSSED SPEEDING TRAFFIC LANES AND CAME TO A STOP ON AN OVER PASS. HAD THE TRUCK TOWED TO THE DEALER. THE DEALER FINDINGS WERE A PROBLEM WITH THE FUEL PUMP AND CONTROLLER. THE DEALER STATED WHEN THEY ENTER THE CHECK ENGINE CODE (P0627) INTO THEIR WAN, THEY SHORTLY HAD A CALL FROM FORD ENGINEERING WANTING THE PARTS RETURNED TO THEM AND WITH INSTRUCTIONS NOT TO REPLACE THEM WITH THE SAME PART NUMBER. IT SEEMS THIS WAS A KNOWN ISSUE AND HAD BEEN FLAGGED IN THEIR NETWORK BY FORD ENGINEERING. IT SEEMS THIS ISSUE WAS UNKNOWN BY THE DEALERSHIP. IT BOTHERS ME…

The vehicle has suffered repeated systemic electrical failures all while being under 8,000 miles. What component/system failed? Power distribution/fuse block, starter, fuel pump control module, horn circuit, body control module, instrument cluster, and charging system. Error codes documented include P0627 (Fuel Pump Control Circuit), U0100 (Lost Comm ECM/PCM), B1325 (Control Module Power Low), U0140 (Lost Comm BCM), and B1000 (ECM fault). All repairs are documented by the dealer, and the truck remains available for inspection. How was safety at risk? The truck lost propulsion at speed, emitted smoke from the engine bay, and became disabled in traffic, placing my family, including my toddler…

The contact owns a 2012 Jeep Grand Cherokee. The contact stated that after starting the vehicle, the vehicle was idling rough idle almost causing the vehicle to stall. The contact stated that while depressing the accelerator pedal, the vehicle seemed to operate and run normally. The contact stated that the check engine and the electronic throttle control warning lights illuminated. The contact stated that after shifting into drive(D) and accelerating to approximately 10 MPH, the vehicle hesitated, revved, and then lunged forward. Additionally, the contact noted that the vehicle had been consuming an unusual amount of coolant that required him to add about one gallon of coolant per month. The…

VAN STALLED WHILE BACKING INTO STREET. THREW CODE P0627. SECOND TIME THIS HAS HAPPENED. FIRST TIME DID NOT INCLUDE STALLING AND CODE CLEARED AFTER A COUPLE DAYS. REPORTING DUE TO STALLING WHILE MOVING IN ROAD.